![Sample our Physical Sciences journals, sign in here to start your FREE access for 14 days]({"type":"image" , "src" : "/sda/110819/TOC-Subject-Sample-2021-Physical-Sciences.jpg"})
Abstract
Nitrogen removal by a methane fermentation plus activated sludge process with the intermittent aeration was presented based upon a full‐scale pig farm experiment. Swine wastewater had a T‐N/BOD ratio from 0.2–0.29. The BOD concentration input to the process ranged from 1050–1608 mg l‐1 and the T‐N concentration from 273–350 mg l‐1. More than 90% of organic carbon was removed in each experimental run. Only small concentrations of NO3‐N were found in the effluent and higher than 60% of the T‐N and 73% of NH4‐N which were loaded to the intermittent aeration tank was removed. The nitrogen balance of each run was calculated. Denitrification was estimated to be accountable for 45–90% of the T‐N removed in the intermittent aeration tank. Denitrification rate increased as the BOD concentration increased (> 1300 mg l‐1). The T‐N removal percentage was a function of the T‐N/BOD ratio of the influent. Although higher DO concentration (> 3 mg l‐1) did not enhance the denitrification rate, nitrification did maintain at relative higher rates at a lower DO concentration (ave. 1.5 mg l‐1). An operational condition of intermittent interval of aeration/nonaeration at 1:1 hr is better than that of the condition at 3:1 hr. As a result, T‐N and NH4‐N were removed up to 30% and 40% respectively, and the denitrification rate reached 79% in the intermittent aeration tank. An experimental run in a pilot plant on treating anaerobically pretreated swine wastewater was observed to verify simultaneous nitrification/denitrification. The results of the full‐scale plant experimentation seem to be confirmed by those obtained from the pilot plant runs.