Migration from polyamide ‘microwave and roasting bags’ into roast chicken

Abstract

Migration of non‐volatile and volatile compounds from ‘microwave and roasting bags’ (MRB), made of Nylon 6,6 (and some Nylon 6), into chicken meat, skin, and juices during roasting (200°C/2 h) in a conventional oven was determined. For measurement of migration of non‐volatile compounds, cooked chicken was freezedried, extracted with methanol after addition of 2‐azacyclononane (internal standard) and the extract cleaned‐up using liquid—solid adsorption chromatography (silica gel). High performance liquid chromatography (HPLC) in the reverse phase mode using a linear gradient of methanol in water was used to quantify seven Nylon 6 and Nylon 6,6 cyclic monomers and oligomers of molecular mass up to 678 daltons. Migration into chicken was 7.48 μg/g (8.26 mg/bag; 3.94 μg/cm²), 16% of the total non‐volatile compounds contained in the MRB material. Individual migrants were also quantified. Migration of one volatile compound, 2‐cyclopentyl cyclopentanone, into the roast chicken parts was measured. Extraction with diethyl ether, using a modified Likens‐Nickerson system of concurrent steam distillation—solvent extraction with an internal standard (cyclohexanone) was performed for 10 h. Gas chromatography/mass spectrometry (GC/ MS) in the selected ion mode (SIM) was used for quantification. An average of 14.0 (±4.36) μg/bag (or μg/chicken) migrated, being 0.08% of the total 2‐cyclopentyl cyclopentanone present in MRB. Loss of volatile compounds to the atmosphere is believed to have occurred since there was another, more volatile compound (cyclopentanone), present in MRB, at levels higher than 2‐cyclopentyl cyclopentanone, but this was not detected in roast chicken. In general, the transference of MRB components into roast chicken can be considered not to present a hazard.

Keywords:

• dual‐ovenable
• migration
• Nylon 6
• Nylon 6,6
• ‘roast‐in‐the‐bag’
• chicken

Notes

To whom correspondence should be addressed.