Performance evaluation of micro-aerobic hydrolysis of mixed sludge: Optimum aeration and effect on its biochemical methane potential

ABSTRACT

This study evaluated the performance of a micro-aerobic hydrolysis of mixed sludge and its influence as a pretreatment of this waste for its subsequent anaerobic digestion. Three experimental series were carried out to evaluate the optimum micro-aeration levels in the range from 0.1 to 0.5 air volume/min.reactor volume (vvm) and operation times within the range of 24–60 h. The maximum methane yield [35 mL CH₄/g volatile suspended solids (VSS) added] was obtained for an aeration level of 0.35 vvm. This methane yield value increased 114% with respect to that obtained with the non-aerated sludge. In the micro-aeration process carried out at an aeration level of 0.35 vvm, increases in soluble proteins and total sugars concentrations of 185% and 192% with respect to their initial values were found, respectively, after 48 h of aeration. At the above micro-aerobic conditions, soluble chemical oxygen demand (COD_S) augmented 150%, whereas VSS content decreased until 40% of their initial respective values. Higher COD increases and VSS decreases were found at 60 h of micro-aeration, but the above parameters did not vary significantly with respect to the values found at 48 h.

KEYWORDS:

• Aerobic hydrolysis
• anaerobic digestion
• methane production
• micro-aeration
• mixed sludge

Funding

The authors acknowledge gratefully the financial support of FONDECYT through Project 1030315 (Chile).