65
Views
1
CrossRef citations to date
0
Altmetric
Original Research

Cost analysis of pulmonary lobectomy procedure: comparison of stapler versus precision dissection and sealant

, , , , , & show all
Pages 201-206 | Published online: 03 Apr 2017

Abstract

Objective

We aimed to evaluate the direct costs of pulmonary lobectomy hospitalization, comparing surgical techniques for the division of interlobar fissures: stapler (ST) versus electrocautery and hemostatic sealant patch (ES).

Methods

The cost comparison analysis was based on the clinical pathway and drawn up by collecting the information available from the Thoracic Surgery Division medical team at Mantova Hospital. Direct resource consumption was derived from a previous randomized controlled trial including 40 patients. Use and maintenance of technology, equipment and operating room; administrative plus general costs; and 30-day use of postsurgery hospital resources were considered. The analysis was conducted from the hospital perspective.

Results

On the average, a patient submitted to pulmonary lobectomy costs €9,744.29. This sum could vary from €9,027 (using ES) to €10,460 (using ST). The overall lower incidence (50% vs 95%, P=0.0001) and duration of air leakage (1.7 days vs 4.5 days, P=0.0001) in the ES group significantly affects the mean time of hospital stay (11.0 days vs 14.3 days) and costs. Cost saving in the ES group was also driven by the lower incidence of complications. The main key cost driver was staff employment (42%), then consumables (34%) and operating room costs (12%).

Conclusion

There is an overall saving of around €1,432.90 when using ES patch for each pulmonary lobectomy. Among patients undergoing this surgical procedure, ES can significantly reduce air leakage incidence and duration, as well as decrease hospitalization rates. However, further multicenter research should be developed considering different clinical and managerial settings.

View correction statement:
Cost analysis of pulmonary lobectomy procedure: comparison of stapler versus precision dissection and sealant [Corrigendum]

Introduction

Lung cancer is a very common malignancy with the peculiar characteristic of high aggressivity and lethality, so it has been called the “big killer”. Pulmonary lobectomy is the operation of choice for the standard treatment of early-stage lung cancer. It encompasses an approach through the pleural cavity and the ligation of the pulmonary artery branches, the pulmonary vein and the bronchus. It is usually considered as the removal of half of the lung.

Although a few studies have supported the evidence of favorable efficacy of fleece-bound sealing, very few trials are aimed at cost analyses. A couple of investigations have been conducted to evaluate health care costs after a pulmonary lobectomy. These analyses have demonstrated that an overall saving of around €100–200 is achieved if fleece-bound sealing procedure is performed instead of the standard techniques of sealing the lung following pulmonary resection.Citation1,Citation2

Nonetheless, no detailed data on the economic impact of fleece-bound sealing during pulmonary lobectomy procedure are currently available, and the incidence of prolonged air leak is variable in the data in the literature. Considering the results from the clinical trial carried out in an Italian Hospital, this study was designed with the aim to give better insight into the definite hospital direct costs by using an activity-based costing approach.Citation2 Costs occurring during hospitalization for alternative surgical techniques to seal interlobar fissures division were analyzed. Stapler (ST) versus electrocautery and hemostatic sealant patch (ES) procedures were performed at the same Italian Hospital and economically compared.

As economical benefit has been reported in the clinical trial, further evaluation of this aspect has been considered a potentially interesting subject to be evaluated in order to clarify the impact on costs of clinical behavior and thus to help physicians perform a safe and sustainable surgery.

Patients and methods

The analysis focuses on the comparative assessment of hospitalization-related direct costs for patients undergoing pulmonary lobectomy using two different surgical management techniques (ST versus ES) to achieve the interlobar fissure dissection. The study was carried out at the Carlo Poma Hospital of Mantova by the Thoracic Surgery medical team, and the cost analysis of both techniques was based on specific economic data collection on the patient population (40 patients, 20 in each group) already enrolled for the previous trial (prospective, randomized), which compared the clinical outcome comparing ST and ES ().Citation2 Use and maintenance of equipment, technology and operating room; the general plus administrative costs; and hospital resources used in the postoperative 30-day period as outpatients, entered the analysis. The total cost for each patient was calculated considering the whole medical process, taken from hospital charts, from the day of first admission at the medical center to the medical evaluation on the postoperative 30th day.

Table 1 Resource consumption

The analysis was conducted from the hospital perspective. The databases used did not contain a variable allowing for the individual identification of patients. According to Italian legislation, this study’s characteristics (observational methodology and retrospective analysis) do not make it necessary to obtain authorization from the hospital ethics committee. In accordance with Italian privacy law (code concerning the protection of personal data, 30 June 2003, n.196) patients were assigned identification numbers for the study, thus eliminating the patient health service codes and avoiding the risk of identifying patients personally. A previous clinical trialCitation2 showed interesting data regarding cost-effectiveness, but the analysis was insufficient to give an accurate sense of the potential economical impact of the different surgical approaches.

Surgery

Two groups of patients (20 patients each) were subjected to pulmonary lobectomy. The interlobar fissure was approached by different techniques. In one group, the fissure was divided by means of mechanical STs, while in the second group, this passage was accomplished using electrocautery for dissection and collagen patches coated with human fibrinogen and thrombin (TachoSil®) for sealing. Lobectomy was performed in the same way for the remaining steps of the procedure.

Resource consumption and cost analysis

Data on material consumption and resource management were analyzed by hospital representatives who are involved in the early-stage non–small cell lung cancer (NSCLC) patient pathway from workup to surgery. For all countable consumables and equipment exploitation in terms of time of use and maintenance, in addition to administrative, general and human resource service, costs were estimated.

Costs per unit were collected directly from hospital accounts where possible, from regional tariffs for specialized services and from hospital admissions where data were not available from the hospital (). Episodes of complications and comorbidities were identified as well, including related resource consumption, and their occurrence was referred to in a previous clinical trial.Citation2 A differential analysis was carried out to identify the variation between using ST versus ES in terms of resource consumption. All costs were updated to the year 2012.Citation3Citation5

Table 2 Unit cost sources

Sensitivity analysis

Single-way sensitivity analysis was performed by varying (±10%) the cost of hemostatic sealant patch to establish the robustness of the model.Citation6,Citation7 Because the difference in mean hospitalization length of the two procedures did not achieve statistical significance, a sensitivity analysis technique was additionally applied to determine the economic value assigned to the ST scenario versus the ES scenario assuming the same length of stay (LOS) for both the situations.Citation6

Results

The hospitalization cost for the pulmonary lobectomy procedure totaled around €9,027.95–10,460.64 and it diverged if surgical ST or ES had been used to complete the interlobar fissures. The amount varied from €9,027 for the ES group to €10,460 for the ST group. The main cost driver was recognized to be the staff time (around 20%), with the consumables (including both STs and patches, around 19%) being the second (). Resource consumption and the consequential costs showed that the difference between the two scenarios, excluding overheads, was mainly due to time spent by involved staff (ES staff cost was 10.2% lower than the staff cost for STs) and drugs used to treat both expected consequences of lobectomy and complications (−20.6%) (). Indeed, the lower overall incidence (50% vs 95%, P=0.0001) and duration of air leakage (1.7 days vs 4.5 days, P=0.0001) in the ES group significantly affected treatment of complications and consequently the mean time to hospital discharge (11.0 days vs 14.3 days) and ultimately the costs ( and ).Citation2 A sensitivity analysis was performed to determine whether variations in the cost of the hemostatic sealant patch (±10%) could influence the results of the cost analysis investigation considering possible regional variation of price. Therefore, the cost of the hemostatic sealant patch was varied (±10%) to determine the circumstances that could logically bring about cost change.

Figure 1 Results: mean cost of procedure.

Figure 1 Results: mean cost of procedure.

Table 3 Results: mean cost per resource type

Results basically remained unremarkable, varying from €8,978 (−10% cost) to €9,077 (+10% cost). In addition, even when the hospital LOS for the ST group was decreased to 11 days (the same situation as that for the ES procedure), the average hospitalization cost using the ES technique was less expensive than that with ST (€9,341 vs €9,028). Higher costs of the ST group depend on consumables and therapies for complications (with higher incidence in ST group vs ES group). Consequently, it could be stated that even if LOS is assumed to be equal between the two groups, ES treatment remained less expensive. No readmission occurred within the 30-day follow-up time.

Discussion

The most commonly performed procedure in the treatment of early-stage NSCLC is pulmonary lobectomy, which currently represents the standard of cure.Citation8 Surgery is considered the preeminent therapeutic option.Citation9Citation11 Complications after lung manipulation are often related to the stressed residual parenchyma and may heavily affect the postoperative course of patients.

One of the important events potentially influencing the healing process after major surgery is persistent air leak from lung parenchyma. This phenomenon is reported to appear in 3%–25% of patients.Citation12 The leakage showed higher incidence when lung fissures were not complete, and it could persist for several days. Surgical dissection of fissure to anatomically divide the two lobes generally is causative of this prolonged air leakage, which requires long-lasting chest drainage. This clinical circumstance hampers recovery and limits hospital discharge.Citation13Citation15 Hence, the negative impact of postoperative morbidity expands the hospital stay period with consequences on the economic aspect.

Over the years, there has been consistent progress in terms of surgical devices and medical products so that surgeons have a spectrum of choices in order to perform each surgical procedure. The panel of options includes STs, traditional suture materials, energy devices or electrocautery unit, in addition to fibrin glue, synthetic polyethylene glycol-based materials and collagen patches coated with fibrinogen and thrombin (TachoSil®; Takeda Pharmaceutical Company, Osaka, Japan).Citation14,Citation16Citation21 Several authors have investigated the topic of fleece-bound sealing with emphasis on efficacy and economical advantage.Citation14,Citation15,Citation17 These studies are international and one is a prospective randomized study performed by a single center;Citation16 these contributions have brought to evidence a significantly lower consistency of the air leakage phenomenon in the early postoperative period when the technique of fleece-bound sealing is performed; consequently early chest tube removal and a shorter hospitalization are reported.Citation15,Citation16

A prospective randomized controlled trial has been performed by an Italian research group to evaluate the comparative outcome of performing the fissure dissection by means of alternative procedures.

Results of such a study were consistent with other international analyses and, significantly greater incidence and severity of intraoperative air leaks were observed in the ES group and a relevant reduction of these on postoperative day 1 after application of TachoSil.Citation17 The use of ES patch (TachoSil) for aerostasis to achieve surgical dissection of pulmonary fissures to accomplish a lobectomy resulted in an overall saving of approximately €1,432.69 compared to the control group. Among all the enrolled patients undergoing surgery, ES was significantly related to reduced incidence of air leakage and duration of such leakage, as well as the in-hospital LOS. This evidence could be highly remarkable considering specific economic arrangements of expense reimbursement, such as the Diagnosis Related Groups system. This may mean that, in situations in which health care providers need to achieve the therapeutic goal besides guaranteeing the optimized use of resources such as as-short-as-possible stay in hospital, the provided clinical services must be at the state-of-the-art but must simultaneously tend to the highest possible level of technical quality, to facilitate the best outcome for the patient along with the best economic management.

These results are comparable with conclusions of other studies as, eg, a recent systematic review summarizing the available evidence for fleece-bound sealing.Citation14Citation18,Citation20,Citation22 The review analyzed 49 publications covering different surgical sectors, with the conclusion that, in addition to clinical benefits, fleece-bound sealing resulted in economic benefits also, such as reduction in time to hospital discharge and complication rates.Citation15 Moreover, the efficacy of fleece-bound tissue gluing to seal air leaks after pulmonary resection and primary leakage closure was evaluated in a prospective, randomized, open-label, parallel-group, single-center study for NSCLC surgery.Citation16 The aim of such a study was to compare fleece-bound sealing (TachoSil, TS) and standard techniques (ST, defined as suture with or without staples) for closure of alveolar air leaks following parenchymal resection. Significant reductions in volume of air leakage in the early postoperative period, with early chest drain removal and time to hospital discharge, were demonstrated after using fleece-bound sealing technique in the subset of patients with recognized intraoperative air leakage.Citation16

The clinical trial by Droghetti et alCitation2 highlighted the benefit of TachoSil patching, which could lead to a reduction of >48 hours in the mean time to chest drain removal and >3 days of hospital stay. Multiple aspects of possible superiority of the use of fleece-bound sealants resulted from the ES group outcome. Among these features, the ability to perform an accurate dissection to preserve as much pulmonary parenchyma as possible allows the residual lung to be larger and to preserve more elasticity, which entails enhanced propensity to refill the thoracic cavity, than after being stapled.Citation17 Such a condition leads to a minor incidence of complications and, with the present cost analysis, it was demonstrated that these benefits also imply cost saving for the health care system.

Despite the quite different results, more specifically concerning total amounts, the evidence produced by this analysis confirmed what was inferred from other economic evaluations carried out in Europe.Citation6,Citation23 These investigations demonstrated how the use of fleece-bound sealants to stop air leakage could reduce the length of hospital stay and what effect this may have on economic impact. In another study, the number and frequency of persistent leakages were also found to be reduced after fleece-bound sealing, but the duration of hospitalization was not examined and no economic comment was given.Citation14 This study has several limitations. The study was performed in a single-center setting and the population included in the study was small. So, several factors could have had some impact in producing biases considering the specific unique environment of a single institution. The number of patients included in the study is limited and this represents a limitation for the investigation. However, the data strongly suggest that using fleece-bound sealing to treat and prevent air leakage after lobectomy is worthwhile from the clinical point of view and from the hospital economic perspective as well.

In the context of local and general previous analyses on cost-effectiveness, this study represents a further experience, but it remains unclear how important the impact could be on cost-effectiveness due to local and national regulations and type of supplies.

Conclusion

In the future, our ability to identify which topical hemostatic agent or surgical sealant should be used in a particular patient will depend increasingly on the quality of information available regarding prevention of postoperative complications in clinical practice and, indirectly, on the possibility of optimizing the use of hospital services. Considering that the study has been performed from the hospital perspective, some specific clinicoeconomical aspects could be delineated to arrange management of materials for a more sustainable and appropriate use of instruments in clinical practice. High-quality information would be necessary to optimize total health expenditure and simultaneously improve patients’ quality of life. From a historical point of view, the analysis of benefits from using new tools and materials in clinical practice is increasingly necessary for resource planning in the future of surgical specialties. This economical and managerial necessity is testified by the increasing number of references (clinical and experimental) supporting innovative, effective and safe use of sealants for different new indications.Citation24Citation28 However, further multicenter research in different clinical and organizational settings would be necessary in order to implement and validate these results.

Acknowledgments

This research was funded by an unrestricted grant from Takeda Italia Spa. We are grateful for the collaboration and support of the Administration of Carlo Poma Hospital, Italy.

Disclosure

The authors are employees of independent research organizations and have maintained independent scientific control over the study, including data analysis and interpretation of final results. The authors report no other conflicts of interest in this work.

References

  • AneggURychlikRSmolle-JüttnerFDo the benefits of shorter hospital stay associated with the use of fleece-bound sealing outweigh the cost of the materialsInteract Cardiovasc Thorac Surg2008729229618055483
  • DroghettiASchiaviniAMurianaPA prospective randomized trial comparing completion technique of fissures for lobectomy: stapler versus precision dissection and sealantJ Thorac Cardiovasc Surg2008136238339118692646
  • Italian Health Economics Association-Associazione Italiana di Economia Sanitaria (AIES)Italian Guidelines proposal on how to conduct economic evaluation studies of health programsPharmacoeconomics2009118393
  • Agenzia Italiana del Farmaco [AIFAItalian Drug Agency] [webpage on the Internet]Negoziazione e rimborsabilitá [Negotiation and reimbursement; web page on the Internet]RomeAIFA2013 Italian. Available from: http://www.agenziafarmaco.gov.it/it/content/negoziazione-e-rimborsabilit%C3%A0Accessed November 13, 2011
  • Istat [webpage on the Internet]Indice dei prezzi al consumo per le rivalutazioni monetarie [Consumer Price Index for inflation adjustments]RomaIstituto nazionale di statistica Available from: http://www.istat.it/it/archivio/30440Accessed November 7, 2013
  • BriggsASculpherMBuxtonMUncertainty in the economic evaluation of health care technologies: the role of sensitivity analysisHealth Econ19943951048044216
  • HusereauDDrummondMPetrouSISPOR Health Economic Evaluation Publication Guidelines-CHEERS Good Reporting Practices Task ForceConsolidated health economic evaluation reporting standards (CHEERS) – explanation and elaboration: a report of the ISPOR Health Economic Evaluation Publication Guidelines Good Reporting Practices Task ForceValue Health201316223125023538175
  • MezzettiMPanigalliTGiulianiLRavegliaFGiudiceFLMedaSPersonal experience in lung cancer sleeve lobectomy and sleeve pneumonectomyAnn Thorac Surg20027361736173912078762
  • DamstrupLPoulsonHSReview of the curative role of radiotherapy in the treatment of non-small cell lung cancerLung Cancer1994113–41531787812695
  • GriliROxmanADJulianJAChemotherapy for advanced non-small cell lung cancer; how much benefit with enough?J Clin Oncol19931118551872
  • RenaOPapaliaEMineoTCAir-leak management after upper lobectomy in patients with fused fissure and chronic obstructive pulmonary disease: a pilot trial comparing sealant and standard treatmentInteract Cardiovasc Thorac Surg20099697397719776082
  • DroghettiASchiaviniAMurianaPAutologous blood patch in persistent air leaks after pulmonary resectionJ Thorac Cardiovasc Surg2006132355655916935110
  • StolzAJSchutznerJLischkeRSimonekJPafkoPPredictors of prolonged air leak following pulmonary lobectomyEur J Cardiothorac Surg200527233433615691692
  • WainJCKaiserLRJohnstoneDWTrial of a novel synthetic sealant in preventing air leaks after lobectomyAnn Thorac Surg2001711623162911383811
  • Serra-MitjansMBelda-SanchisJRami-PortaRSurgical sealant for preventing air leaks after pulmonary resections in patients with lung cancerCochrane Database Syst Rev2005203CD00305110.1002/14651858.CD003051.pub2
  • FabianTFedericoJAPonnRBFibrin glue in pulmonary resection: a prospective randomized blinded studyAnn Thorac Surg20037551587159212735583
  • FleisherAGEvansKGNelemsBFinleyRJEffect of routine fibrin glue use on the duration of air leaks after lobectomyAnn Thorac Surg19904911331342297261
  • WongKGoldstrawPEffect of fibrin glue in the reduction of postthoracotomy alveolar air leakAnn Thorac Surg19976449799819354513
  • MacchiariniPWainJAlmySDartevellePExperimental and clinical evaluation of a new synthetic, absorbable sealant to reduce air leaks in thoracic operationsJ Thorac Cardiovasc Surg1999117475175810096971
  • PorteHLJanyTAkkadRRandomized controlled trial of a synthetic sealant for preventing alveolar air leaks after lobectomyAnn Thorac Surg20017151618162211383810
  • LangGCsekeoAStamatisGEfficacy and safety of topical application of human fibrinogenythrombin-coated collagen patch (TachoComb) for treatment of air leakage after standard lobectomyEur J Cardiothorac Surg20042516016614747106
  • RychlikRZur Nutzenbewertung der Gewebeklebung in der Chirur-gie–das Beispiel TachoSil [For the benefit assessment of tissue adhesion in the Surgery- the example TachoSil]Krankenhauspharmazie20065199204 German
  • CarbonRTBaarSWaldschmidtJHümmerHPSimonSMinimalin-vasive Kinderchirurgie: Entwicklung und Fortschritt durch innovative Technologie. Die ATCS-Klebung [Minimal invasive paediatric surgery: further advances through innovative technology. ATCS sealing]Klin Pädiatr200121399103 German11417369
  • ColomboGLBettoniDDi MatteoSEconomic and outcomes consequences of TachoSil®: a systematic reviewVasc Health Risk Manag20141056957525246797
  • VannucciJDroghettiABufalariAEffectiveness and predictability of pleurodesis with the Tachosil® surgical patch compared with talc poudrage: an experimental studyEur J Cardiothorac Surg201650466867427107043
  • GiordanoRPalmaGPalumboSUse of biological hemostatic support TachoSil® for reoperation in pediatric cardiac surgeryMinerva Pediatr201668324024127125443
  • MaranoLDi MartinoNEfficacy of human fibrinogen-thrombin patch (TachoSil) clinical application in upper gastrointestinal cancer surgeryJ Invest Surg201629635235827191688
  • FengWCoadyMEpicardial Tachosil patch repair of ventricular rupture in a 90-year-old after mitral valve replacementAnn Thorac Surg201610162361236327211944