Condensation in Microchannels

REFERENCES

• Cotter , T.P. . Principles and Prospects of Micro Heat Pipes . Proceedings of the 5th International Heat Pipe Conference . pp. 328 – 332 .
   Google Scholar
• Peterson , G.P. , Duncan , A.B. and Weichold , M.H. 1993 . Experimental Investigation of Micro Heat Pipes Fabricated in Silicon Wafers . Journal of Heat Transfer , 115 ( 3 ) : 750 – 756 .
   Google Scholar
• Peterson , G.P. 1994 . An Introduction to Heat Pipes: Modeling, Testing, and Applications , New York : John Wiley .
   Google Scholar
• Peterson , G.P. 2001 . The MEMS Handbook , Edited by: Gad-el-Hak , M. chap. 31, CRC Press .
   Google Scholar
• Cheng , P. and Wu , H.Y. 2006 . Mesoscale and Microscale Phase Change Heat Transfer . Advances in Heat Transfer , 39 : 469 – 573 .
   Google Scholar
• Argyropoulos , P. , Scott , K. and Taama , W.M. 1999 . Carbon Dioxide Evolution Patterns in Direct Methanol Fuel Cells . Electrochimica Acta , 44 ( 20 ) : 3575 – 3584 .
   Google Scholar
• über , K. T , ócza , D. P and Hebling , C. 2003 . Visualization of Water Buildup in the Cathode of a Transparent PEM Fuel Cell . Journal of Power Sources , 124 ( 2 ) : 403 – 414 .
   Google Scholar
• Berning , T. , Djilali , N. and Multiphase , A. 3D . 2003 . Multicomponent Model of the Cathode and Anode of A PEM Fuel Cell . Journal of the Electrochemical Society , 150 ( 12 ) : A1589 – A1598 .
   Google Scholar
• Galbiati , L. and Andreini , P. 1994 . Flow Pattern Transition for Horizontal Air-Water Flow in Capillary Tubes—A Microgravity Equivalent System Simulation . International Communications in Heat and Mass Transfer , 21 ( 4 ) : 461 – 468 .
   Google Scholar
• Schmidt , G.R. , Chung , T.J. and Nadarajah , A. 1995 . Thermocapillary Flow with Evaporation and Condensation at Low Gravity . Journal of Fluid Mechanics , 294 : 323 – 347 . Part 1. Non-Deforming Surface,
   Web of Science ®Google Scholar
• Schmidt , G.R. , Chung , T.J. and Nadarajah , A. 1995 . Thermocapillary Flow with Evaporation and Condensation at Low Gravity . Journal of Fluid Mechanics , 294 : 349 – 366 . Part 2. Deformable Surface,
   Google Scholar
• Wu , H.Y. and Cheng , P. 2003 . An Experimental Study of Convective Heat Transfer in Silicon Microchannels with Different Surface Conditions . International Journal of Heat and Mass Transfer , 46 : 2547 – 2556 .
   Web of Science ®Google Scholar
• Kandlikar , S.G. and Grande , W.J. 2004 . Evaluation of Single Phase Flow in Microchannels for High Heat Flux Chip Cooling—Thermohydraulic Performance Enhancement and Fabrication Technology . Heat Transfer Engineering , 25 ( 8 ) : 5 – 16 .
   Web of Science ®Google Scholar
• Obot , N.T. 2002 . Toward a Better Understanding of Friction and Heat/Mass Transfer in Microchannels—A Literature Review . Microscale Thermophysical Engineering , 6 ( 3 ) : 155 – 173 .
   Web of Science ®Google Scholar
• Thome , J.R. 2004 . Boiling in Microchannels: A Review of Experiment and Theory . International Journal of Heat and Fluid Flow , 25 ( 2 ) : 128 – 139 .
   Google Scholar
• Wu , H.Y. and Cheng , P. 2004 . Boiling Instabilities in Parallel Silicon Microchannels at Different Heat Flux . International Journal of Heat and Mass Transfer , 47 : 3631 – 3641 .
   Web of Science ®Google Scholar
• Palm , B. 2001 . Heat Transfer in Microchannels . Microscale Thermophysical Engineering , 5 ( 3 ) : 155 – 175 .
   Web of Science ®Google Scholar
• Cavallini , A. , Censi , G. , Del Col , D. , Doretti , L. , Longo , A.G. and Rossetto , L. . Condensation Heat Transfer and Pressure Drop inside Channels for AC/HP Application . Proceedings of 12th International Heat Transfer Conference . Vol. 1 , pp. 171 – 186 .
   Google Scholar
• Suo , M. and Griffith , P. 1964 . Two-Phase Flow in Capillary Tubes . Journal of Basic Engineering , 86 ( 3 ) : 576 – 582 .
   Google Scholar
• Dukler , A.E. , Fabre , J.A. , Mcquillen , J.B. and Vernon , R. 1988 . Gas-Liquid Flow at Microgravity Conditions—Flow Patterns and Their Transitions . International Journal of Multiphase Flow , 14 ( 4 ) : 389 – 400 .
   Google Scholar
• Dukler , A.E. and Hubbard , M.G. 1975 . A Model for Gas-Liquid Slug Flow in Horizontal and Near Horizontal Tubes . Industrial & Engineering Chemistry Fundamentals , 14 ( 4 ) : 337 – 347 .
   Google Scholar
• Garimella , S. 2004 . Condensation Flow Mechanisms in Microchannels: Basis for Pressure Drop and Heat Transfer Models . Heat Transfer Engineering , 25 ( 3 ) : 104 – 116 .
   Web of Science ®Google Scholar
• édéric , B. M , Miscevic , M. and Platel , V. 2004 . Experimental Study of Flow Characteristics during Condensation in Narrow Channels: The Influence of the Diameter Channel on Structure Patterns . Superlattices and Microstructures , 35 ( 3–6 ) : 573 – 586 .
   Google Scholar
• édéric , B. M , Miscevic , M. and Miscevic , M. 2005 . Void Fraction Invariance Properties of Condensation Flow Inside a Capillary Glass Tube . International Journal of Multiphase Flow , 31 ( 9 ) : 1049 – 1058 .
   Google Scholar
• Chen , Y.P. and Cheng , P. 2005 . Condensation of Steam in Silicon Microchannels . International Communications in Heat and Mass Transfer , 32 ( 1–2 ) : 175 – 183 .
   Google Scholar
• Wu , H.Y. and Cheng , P. 2005 . Condensation Flow Patterns in Silicon Microchannels . International Journal of Heat and Mass Transfer , 48 ( 11 ) : 2186 – 2197 .
   Web of Science ®Google Scholar
• Garimella , S. and Bandhauer , T.M. . Measurement of Condensation Heat Transfer Coefficients in Microchannel Tubes . Proceedings of the Heat Transfer Division: Fluid-Physics and Heat Transfer for Macro- and Micro-Scale Gas-Liquid and Phase-Change Flows . Vol. 369, no.3 , pp. 243 – 249 .
   Google Scholar
• Yan , Y.Y. and Lin , T.F. 1999 . Condensation Heat Transfer and Pressure Drop of Refrigerant R-134a in a Small Pipe . International Journal of Heat and Mass Transfer , 42 ( 4 ) : 697 – 708 .
   Web of Science ®Google Scholar
• Cavallini , A. , Del Col , D. , Doretti , L. , Matkovic , M. , Rossetto , L. and Zilio , C. . Condensation Heat Transfer Inside Multi-Port Minichannels . Proceedings of the 2nd International Conference on Microchannels and Minichannels . pp. 625 – 632 .
   Google Scholar
• Moser , K.W. , Webb , R.L. and Na , B. 1998 . A New Equivalent Reynolds Number Model for Condensation in Smooth Tubes . Journal of Heat Transfer , 120 ( 2 ) : 410 – 417 .
   Web of Science ®Google Scholar
• Zhang , M. and Webb , R.L. 2001 . Correlation of Two-Phase Friction for Refrigerants in Small-Diameter Tubes . Experimental Thermal and Fluid Science , 25 ( 3–4 ) : 131 – 139 .
   Web of Science ®Google Scholar
• Cavallini , A. , Censi , G. and Del Col , D. 2002 . Condensation of Halogenated Refrigerants inside Smooth Tubes . HVAC & R Research , 8 ( 4 ) : 429 – 451 .
   Web of Science ®Google Scholar
• Kim , M.H. , Shin , J.S. , Huh , C. , Kim , T.J. and Seo , K.W. . A Study of Condensation Heat Transfer in a Single Mini-Tube and a Review of Korean Micro- and Mini-Channel Studies . Proceedings of the 1st International Conference on Microchannels and Minichannels . Vol. 1 , pp. 47 – 58 .
   Google Scholar
• Begg , E. , Holley , B. and Faghri , A. 2003 . Condensation Heat Transfer and Pressure Drop Measurements in Miniature Horizontal Tubes with Low Mass Flux Rates . Journal of Enhanced Heat Transfer , 10 ( 3 ) : 335 – 354 .
   Google Scholar
• Yang , C.Y. and Webb , R.L. 1996 . Condensation of R-12 in Small Hydraulic Diameter Extruded Aluminum Tubes with and without Micro-Fins . International Journal of Heat and Mass Transfer , 39 ( 4 ) : 791 – 800 .
   Google Scholar
• Nusselt , W. 1916 . Die Oberflachen Kondensation des Wasserdampfes . Zeitsehrift Vereines Deutscher Ingeniuere , 60 ( 2 ) : 541 – 569 .
   Google Scholar
• Shah , M.M. 1979 . General Correlation for Heat Transfer during Film Condensation inside Pipes . International Journal of Heat and Mass Transfer , 22 ( 4 ) : 547 – 556 .
   Web of Science ®Google Scholar
• Straub , J. 1994 . The Role of Surface-Tension for 2-Phase Heat and Mass-Transfer in the Absence of Gravity . Experimental Thermal and Fluid Science , 9 ( 3 ) : 253 – 273 .
   Web of Science ®Google Scholar
• Tabatabai , A. and Faghri , A. 2001 . A New Two-Phase Flow Map and Transition Boundary Accounting for Surface Tension Effects in Horizontal Miniature and Micro Tubes . Journal of Heat Transfer , 123 ( 5 ) : 958 – 968 .
   Google Scholar
• Li , J.M. and Wang , B.X. 2003 . Size Effect on Two-Phase Regime for Condensation in Micro/Mini Tubes . Heat Transfer-Asian Research , 32 : 65 – 71 .
   Google Scholar
• Peles , Y.P. and Haber , S. 2000 . A Steady-State, One-Dimensional, Model for Boiling Two Phase Flow in Triangular Micro-Channel . International Journal of Multiphase Flow , 26 ( 7 ) : 1095 – 1115 .
   Google Scholar
• Peterson , G.P. and Ma , H.B. 1999 . Temperature Response of Heat Transport in a Micro Heat Pipe . Journal of Heat Transfer , 121 ( 2 ) : 438 – 445 .
   Google Scholar
• Begg , E. , Khrustalev , D. and Faghri , A. 1999 . Complete Condensation of Forced Convection Two-Phase Flow in a Miniature Tube . Journal of Heat Transfer , 121 ( 4 ) : 904 – 915 .
   Google Scholar
• Wang , B.X. and Du , X.Z. 2000 . Condensation on the Outside Surface of a Small/Mini Diameter Tube for Vapor Flowing through a Horizontal Annulus Surround by an Adiabatic Concentric Tube . International Journal of Heat and Mass Transfer , 43 ( 8 ) : 1391 – 1398 .
   Web of Science ®Google Scholar
• Zhang , Y.W. and Faghri , A. 2001 . Numerical Simulation of Condensation on a Capillary Grooved Structure . Numerical Heat Transfer, Part A-Applications , 39 ( 3 ) : 227 – 243 .
   Google Scholar
• Zhao , T.S. and Liao , Q. 2002 . Theoretical Analysis of Film Condensation Heat Transfer inside Vertical Mini Triangular Channels . International Journal of Heat and Mass Transfer , 45 ( 13 ) : 2829 – 2842 .
   Web of Science ®Google Scholar
• Yang , C.Y. and Webb , R.L. 1997 . A Predictive Model for Condensation in Small Hydraulic Diameter Tubes Having Axial Micro-Fins . Journal of Heat Transfer , 119 ( 4 ) : 776 – 782 .
   Google Scholar
• Garimella , S. and Killion , J.D. 2002 . An Experimentally Validated Model for Two-Phase Pressure Drop in the Intermittent Flow Regime for Circular Microchannels . Journal of Fluids Engineering , 124 ( 1 ) : 205 – 214 .
   Web of Science ®Google Scholar
• Garimella , S. , Killion , J.D. and Coleman , J.W. 2004 . Erratum: “An Experimentally Validated Model for Two-Phase Pressure Drop in the Intermittent Flow Regime for Circular Microchannels,” . Journal of Fluids Engineering , 126 ( 4 ) : 707 – 707 .
   Google Scholar
• Garimella , S. , Killion , J.D. and Coleman , J.W. 2003 . An Experimentally Validated Model for Two-Phase Pressure Drop in the Intermittent Flow Regime for Noncircular Microchannels . Journal of Fluids Engineering , 125 ( 5 ) : 887 – 894 .
   Web of Science ®Google Scholar
• Garimella , S. , Killion , J.D. and Coleman , J.W. 2004 . Erratum: “An Experimentally Validated Model for Two-Phase Pressure Drop in the Intermittent Flow Regime for Noncircular Microchannels,” . Journal of Fluids Engineering , 126 ( 4 ) : 708 – 708 .
   Google Scholar
• Churchill , S.W. 1977 . Friction-Factor Equation Spans All Fluid-Flow Regimes . Chemical Engineering , 84 ( 24 ) : 91 – 92 .
   Web of Science ®Google Scholar
• Wang , W.W.W. , Radcliff , T.D. and Christensen , R.N. 2002 . A Condensation Heat Transfer Correlation for Millimeter-Scale Tubing with Flow Regime Transition . Experimental Thermal and Fluid Science , 26 ( 5 ) : 473 – 485 .
   Web of Science ®Google Scholar
• Rose , J.W. and Le Fevre , E.J. . A Theory of Heat Transfer by Dropwise Condensation . Proceedings of the 3rd International Heat Transfer Conference . Vol. 2 , pp. 362 – 375 .
   Google Scholar
• Okorn-Schmidt , H.F. 1999 . Characterization of Silicon Surface Preparation Processes for Advanced Gate Dielectrics . IBM Journal of Research and Development , 43 ( 3 ) : 351 – 365 .
   Google Scholar
• Kedzierski , M.A. and Goncalves , J.M. 1999 . Horizontal Convective Condensation of Alternative Refrigerants within a Micro-Fin Tube . Journal of Enhanced Heat Transfer , 6 ( 2–4 ) : 161 – 178 .
   Web of Science ®Google Scholar
• Sabry , M.-N. 2000 . Scale Effects on Fluid Flow and Heat Transfer in Microchannels . IEEE Transactions on Components and Packaging Technologies , 23 ( 3 ) : 562 – 567 .
   Google Scholar
• Kang , S.W. , Chen , J.S. and Hung , J.Y. 1998 . Surface Roughness of (110) Orientation Silicon Based Micro Heat Exchanger Channel . International Journal of Machine Tools & Manufacture , 38 ( 5–6 ) : 663 – 668 .
   Google Scholar
• Yang , C.R. , Yang , C.H. and Chen , P.Y. 2005 . Study on Anisotropic Silicon Etching Characteristics in Various Surfactant-Added Tetramethyl Ammonium Hydroxide Water Solutions . Journal of Micromechanics and Microengineering , 15 ( 11 ) : 2028 – 2037 .
   Google Scholar
• Chen , Y.P. and Cheng , P. 2003 . Fractal Characterization of Wall Roughness on Pressure Drop in Microchannels . International Communications in Heat and Mass Transfer , 30 ( 1 ) : 1 – 11 .
   Google Scholar
• Matsuura , T. , Liu , X.W. and Braithwaite , N.S. . Nanoporous Silicon Fabricated by a Novel Method with Cation Complexes in Hydrofluoric Acid Solutions . Microscopy of Semiconducting Materials 2003 Institute of Physics Conference Series . Vol. 180 , pp. 437 – 440 .
   Google Scholar
• Paul , R. and Rieger , H. 2005 . Condensation Phenomena in Nanopores: A Monte Carlo Study . Journal of Chemical Physics , 123 ( 2 ) : 024708
   PubMedGoogle Scholar
• Du , X.Z. and Zhao , T.S. 2003 . Analysis of Film Condensation Heat Transfer inside a Vertical Micro Tube with Consideration of the Meniscus Draining Effect . International Journal of Heat and Mass Transfer , 46 ( 24 ) : 4669 – 4679 .
   Google Scholar
• Wang , H.S. and Rose , J.W. 2005 . A Theory of Film Condensation in Horizontal Noncircular Section Microchannels . Journal of Heat Transfer , 127 ( 10 ) : 1096 – 1105 .
   Web of Science ®Google Scholar